Investigation of appropriate packaging material and shelf-life stability of Moringa oleifera leaf powder
Abstract
Moringa oleifera, a tropical plant produces leaves that contain high levels of vitamin A and protein in addition to other vitamins and minerals. Hence its leaves are dried, milled and used as a food supplement in several countries. However, the stability of the nutrients during storage has not been much investigated. The objective of this study is to determine the appropriate packaging material and shelf-life stability of M. oleifera leaf powder. M. oleifera leaves were solar dried and milled into powder. After the initial analysis, the powder was weighed in aluminium foil, high density polythene and low density polythene sachets. Each was put into a paper envelope and sealed off. The envelopes were put on shelves in a kitchen cabinet and sampled at two month intervals for nutrient analysis. Protein and moisture were determined by proximate method; vitamin C by indophenol method; beta-carotene and alpha-tocopherol by HPLC. pH was measured with a pH meter; water activity by dielectric and conductivity method; mould and yeast by ISO 7954 (1987) and aflatoxin by HPLC. The results showed that protein levels did not vary with time and mode of storage; vitamin C was lost after two months of storage with all packaging materials. Beta-carotene and alpha-tocopherol levels reduced to about half the initial value after six months.
References
Babu Suresh Chamba. 2000. Rural nutrition intervention with indigenous plant foods - a case study of vitamin A deficiency in Malawi. Biotechnol.Agron. Soc. Environ., 4(3):169-179.
Duke JA. 1978. The quest for tolerant germplasm. P 1-61. In: ASA Special Symposium 32, Crop tolerance
to suboptimal land conditions. Am. Soc. Agron. Madison, W.I. Retrieved from: http://newcrop.hort.purdue.edu/newcrop/duke_energy/Moringa_oleifera.html.
Fahey JW. 2005. Moringa oleifera: A review of the Medical Evidence for Its Nutritional, Therapeutic and Prophylactic Properties, Part 1. Trees for Life Journal. www.TFJournal.org.
Fuglie LJ. 1999. The Miracle Tree: Moringa oleifera: Natural Nutrition for the Tropics. Church World Service, Dakar. 68; revised in 2001 and published as The Miracle Tree: The Multiple Attributes of Moringa, 172. http://www.echotech.org/
Ghana Standard Board. 2009. Ghana Standard. Medicinal Plants - Specifications for Moringa Leaf Products. FDGS 998.
Ghana Standard Board. 2009. Ghana Standard. Medicinal Plants - Code of Practice for the production Moringa leaf products FDGS 999.
Glover-Amengor M and Mensah F. 2012. Nutritional evaluation of Moringa oleifera leaves using three drying methods. Journal of Research in Biology 2(5):469-473.
ISO 7984. 1987. (E). Enumeration of yeasts and moulds – Simple plate count method.
Jongrungruangchok S, Bunrathep S and Songsak T. 2010. Nutrients and Minerals Content of Eleven Different Samples of Moringa oleifera Cultivated in Thailand. J Health Res., 24(3):125.
Mensah Maxwell. 2011. Effect of different packaging materials on the quality and shelf life of Moringa (Moringa oleifera) leaf powder during storage. M.Sc. Thesis 87.
Makkar HPS and Becker K. 1997. Nutrient and antiquality factors in different morphological parts of the Moringa oleifera tree. The Journal of Agricultural Science 128:311-322.
Pons WA. 1979. High Pressure Liquid Chromatography determination of aflatoxins in corn. J. AOAC Int.., 62:586, 594
Rodriguez-Amaya DB and Kimura M. 2004. HarvestPlus Handbook for Carotenoid Analysis. HarvestPlus Technical Monograph Series2. International Food Policy Research Institute (IFPRI) and International Center for Tropical Agriculture (CIAT).
Saint Saveur. 2010. Armelle (de), Broin, Melanie (eds). MORINGA Growing and processing moringa leaves. Moringanews/ Moringa Association of Ghana. 15-29.
